Suspension:Seizes/Sticks/Binds
Original Note: hydraulic system not working properly
unit tilts when sitting will not stay level-ds front makes noise when operating and when all legs are down tank
is empty-and tank is full when up. * we had unit leveled with the slide out for 1 whole day and we were unable to replicate this issue. customer requested that we let the factory know about this issue
LEFT REAR SUSPENSION IS LOWER THAN THE RIGHT SIDE AND LIGHT IN THE CENTER CONSOLE STAYS ON INTERMITTENT SEE HISTORY * NO CODES FOUND IN SYSTEM, FOUND UPDATE NEEDED FOR GATEWAY MODULE, REMOVED CENTER FLOOR CONSOLE, INSPECTED WIRES TO THE MAIN PANEL-GOOD. FOUND GATEWAY MODULE NOT PROPERLY COMMUNICATING BETWEEN TCCM AND AND OTHER MODULES. UPDATED GATEWAY MODULE
THE FRONT SHOCK IS NOT WORKING * CAUSE - FRONT SHOCK LOST TENSION AND ALLOWS LIDS TO SLAM CLOSED. CORRECTION - REPLACE SHOCK. TECH STATES THE FRONT SHOCK HAS BEEN REPLACED
CUST STATES THAT THE REAR AXLE LOCK WILL RANDOMLY LOCK. * 6929 could not duplicate 85410303 0.90 test drove 10 miles axle locker light did not come on, scanned vehicle and found no dtcs, verified axle locker functions and is engaging and disengaging locker,
lifted vehicle and inspected and wiggle tested wiring going to locker, no issues found, checked locker connector and connector pins are ok and connector fully seated, at this time can not duplicate concern.
Axle locks * Test drove 10 miles, lock light never came. lift truck and wessle test wing top locker, a l turned ask lock and verified angages and drug... could not dublicate concern at this time. No DTCS.
THE AIR SUSPENSION -IS STUCK IN POSITION, WITH WARNING LIGHT ON * G60 FOUND C1A20-64, AIR LEAK LOCATED IN BAFFLE AT COMPRESSOR, REPLACED EXPANSION TANK ON COMPRESSOR, UPDATED CHCM