Exhaust:Noisy
EXHAUST SELECTION MODE NOT AVAILABLE,
THE PROBLEM IS INTERMITTENT MUFFLER. * BCE TEST NO CODE SYMPTOM CHART AYES A2YE A3YES FOUND MUFFLER INTERN STUCK REMOVED AND REPLACED ASSY AND RETEST OPERATION CHECK OK BODY/CHASSIS/ELECTRICAL - DIAGNOSTIC PINPOINT TEST MUFFLER - REPLACE.
EXHAUST SYSTEM RATTLING * CENTER SHIELDS LOOSE
CENTER PIPE
PIPE-EXHAUST -CTR
BOLT-FLANGt-8X40-R0
GASKFT-EXHAUST PIPE
BOLT-WASHFR ASSEMBL
SEAL R1NC-EXHAUST P
SPRING-EXHAUST FR P
BOLT-EXHAUST PIPE
ON COLD START CHECK FOR LOAD RATTLING NOISE FROM EXHAUST AND IT SHAKING BAD * 15926 VERIFY CONCERN FOUND FLEX PIPES RATTLING ON START UP BOTH SIDES ,CHECKED OASIS FOUND TSB 20-2282 ,INSTRUCTED TO INSTALL HOSE CLAMPS ON FLEX PIPES RE-TEST OK TEST DROVE OK
VEHICLE SOUNDS LOUDER THAN NORMAL LIKE AIR BRAKE AT TIMES * DIAGNOSIS PERFORMED AFTER ROAD TEST FOUND CLAMP BETWEEN CATALYTIC CONVERTOR Y PIPE AND EXHAUST PIPE SEPARATED REPLACE FAILED CLAMP AND VERIFY NOISE CONCERN RESOLVED
noise when engine braking checked and could hear noise from RH exhaust manifold. * removed and replaced RH exhaust manifold gaskets.
SAME RATTLE AS BEFORE. * VERIFIED POTENTIAL RATTLE. HEAT SHIELD ON CENTER PIPE.
NOISE IN REAR WHEN IN REVERSE CHECK * REPLACED MUFFLER ASSEMBLY AND TEST DROVE.
SINCE LAST REPAIR EXHAUST SOUNDS LOUD WHEN STARTING COLD * 4050960 WARM UP THREE-WAY CATALYTIC CONVERTER REPLACEMENT. 41418 CONVERTER TO TURBO SEAL LEAKING REPLACE CAT CONVERTER SEAL TO TURBO
flex pipe rattle * SOLB SEE OTHER LINE - LINE ABOVE. 5349 HALL,MICHAEL LIC#: 7632 ISE 15926 SEE LINE Ð
REPLACE 1 EXHAUST STUD AND NUT PER AUTHORIZATION * REPLACE 1 EXHAUST STUD AND NUT
PARTS IN FRONT EXHAUST PIPE HEAT SHIELDS DETERIORATED / LOOSE / NOISEY * REPLACED FRONT PIPE
A CUST STATES THERE IS A RATTLE UP HILLS AT TIMES * FOUND FRONT EXHAUST HANGER MAKING CONTACT WITH THE SUBFRAME 4050420 EXHAUST FRONT PIPE REPLACEMENT. REPLACE FRONT EXHAUST PIPE
С CUSTOMER STATES THAT THERE IS A TICKING NOISE. PASSENGER SIDE WHEN IT IS RUNNING. SOUNDS LIKE AN EXHAUST LEAK. * 1000 UNABLE TO DUPLICATE CUSTOMER CONCERN AT THIS TIME.
EXHAUST SYS . THE CUSTOMER STATES WHEN DRIVING AT TIMES THERE IS BLACK SMOKE COMING OUT THE TAILPIPE C/A * Module, Powertrain Control (PCM) -
Reprogram ModulePowertrain: Control . (PCM) -
Reprogram (0 - Low Skilled) 2 9 9562; DAILEY II, DEAN A LIC#: M2409-33TEST DROVE AND INSPECTED VEHICLE NO CODES INSPECTED SOFTWARE LEVEL AND FOUND OUT OF DATE THE VEHICLE SEEMS TO RUN A LITTLE RICH
FLASH UPDATED PCM . TEST DROVE VEHICLE OK AT THIS TIME.
Making strange noise when backing and when starting on something is rattling. can hear noise in house * Verified noise, isolated to front exhaust pipe. heat shielding cracked/ noisy
FRONT EXHAUST PIPE