External Body/Trim/Paint:Binds/Seized/Sticks
rear passenger door would not open from the outside or the inside, customer does not use the child locks, happened once. * Couldn't duplicate problem tested door about 30
times. If customer has problems with doors again.
Bring in to dealer
C/S right Front door handle is sticking when trying to
OPEN * 2421602 Cap/Bezel, handle door outside - Replace. 8690 customer states the rf door handle is wiggly? removed the door card and carrier plate and found the bolt that tightens the handle has the head snapped off. replaced the door handle bracket, now the handle isn't wiggly anymore
18N03 DOOR LATCH FREEZING CONCERNS
STICKING DOOR. * REPLACE DOOR LATCH PERFORMED FORD RECALL 18N03 INSTALLED DOOR LATCH AND HANDLES SEALING PERFORMED DOOR LATCH FREEZING CONCERN REPAIRS IN ALL FOUR DORS.
THE REAR SLIDING GLASS OPENS SLOWLY THEN GETS STUCK OPEN * seal inspect, found rear sliding window is difficult to open, performed star case S1923000051, replaced sliding glass upper seal, retest, the window now works properly
THE DOOR WON'T OPEN WHEN ITS COLD OUTSIDE. * COULD NOT DUPLICATE CONCERN
ENTRY DOOR WAS VERY DIFFICULT TO OPEN THEN ONE TIME IT JUST SWUNG OPEN WHILE DRIVING DOWN THE ROAD * VERIFIED CONCERN.  LUBED LOCK AND ADJUSTED LATCH, COMPLETE
TRIM LEFT REAR DOOR HARD TO OPEN AND CLOSE MOST OF THE TIME ACTUAL SWINGING MOTION. * Ir hold open binds 3073 lube Ir hold the open link
WHEN OPENING THE REAR WINDOW THE GLASS IS BINDING AND HAS TO BE STRAIGHTENED MANUALLY BEFORE CLOSING * faulty rear window inspect rear window operation, found sliding glass binding at the top, star case was performed on the last visit to replace the upper run channel, the problem still exists, rear window assembly needs replaced, work to be performed by an outside glass shop
LEFT REAR DOOR DOES NOT OPEN FROM OUTSIDE OR INSIDE * FOUND LEFT REAR DOOR LATCH FAULTY, ORDERED PART
THE PASSENGER SIDE WINDOW IS NOT COMING UP. * ANTI TRAP FAULT PER KARMA DISASSEMBLE DOOR FOR INSPECTION. DURING INSPECTION FOUND THAT SLIDE RAILS AND SEALS ARE ALL INTACT. ALL MEASUREMENTS ARE WITHIN SPEC. READJUSTED PASSENGER WINDOW GLASS. THE WINDOW PERFORMS AS DESIGNED. ACTIVATED ONE TOUCH FUNCTION MULTIPLE TIMES TO VERIFY REPAIR.
driver door not close * Duplicated customer concern, proceeded to replace left front door latch as per door not latching/closing properly. Also, the release actuator was replace due to it not functioning/pulling at the correct force to open the door. Correction: Latch - Door - Front - LH - 2nd Generation (Remove & Replace)
DRIVER'S DOOR DOESN'T ALWAYS LATCH SHUT. * CUSTOMER TO RETURN FOR DIAGNOSIS.
Bumper is curved in at the top middle Passenger area where front lid meets bracket arm the molding or cover is all smashed in and not covering bottom windshield arm/strut * Diagnosed and Performed HeavyExterior Component/Panel Adjustment. Verified Proper Operation. Correction: General Diagnosis
Correction: Exterior Component/Panel/Glass Adjustment - 0.6
C/S DRIVER'S FRONT DOOR WILL NOT CLOSE. * REPLACE FAILED DRIVERS DOOR LATCH ASSEMBLY 0.60 0.6hr TECH  9145(70503000=0.5hr) REPLACED DRIVERS DOOR LATCH ASSEMBLY (70501209=0.1hr)CARRIED OUT ADJUSTMENT OF DOOR STRIKER AS TSS#1661867
PASSENGER REAR DOOR GETS STUCK AND WOULD NOT SHUT. IT IS WORKING NOW BUT THE CUSTOMER IS CONCERNED THAT IT MIGHT HAPPEN AGAIN. * Technician Inspected door operation and door/trim condition. The door Is operating according to factory specification.